Diesel truck enthusiast and mechanic. Check out our diesel performance online shop.
The most common mechanical problem with the 98.5-2002 Dodge Cummins was failure of the Bosch Vp44 injection pump and lift pump. Over the years these have been notorious for going out and costing consumers a lot of money, especially if you take your truck back to the dealer, repair cost usually average about $3000. There are three common mechanical failures of the VP44 injection pump:
The most common mechanical failure of the VP44 pump is rupturing of the diaphragm in the front of the injection pump. The diaphragm ruptures allowing the timing piston to vibrate and damage the front cover until fuel bypasses. This will cause the dreaded check engine trouble code P0216. When this occurs your Bosch VP44 Injection Pump must be replaced. The rupturing of the diaphragm is caused by a poorly designed lift pump. When the lift pump does not supply the Injection pump with the correct amount of Fuel Pressure (a minimum of 5psi under load at wide open throttle) the diaphragm then doesn’t have enough positive pressure and ruptures. Dodge has recognized this problem as they will no longer even sell the lift pump that goes on the side of the block, they replace it with a unit that is now mounted in the tank. The average cost of having the lift pump put in the tank is about $800.
The next most common mechanical failure of the VP44 is that the rotor seizes in the head of the pump. This again can be contributed to the lift pump not providing enough fuel to the injection pump. Diesel Fuel is used as a lubricant , so when there is a insufficient amount of fuel the rotor does not get lubricated properly. If the rotor seizes the truck wont start and the VP44 Injection Pump must be replaced.
The last reason for the failure of the VP44 pump is electrical problems with the computer on top of the pump. Heat is the main reason associated with this problem, causing the soldered components to become crystallized over time and make bad connections. Lack of fuel is again part of the problem, because the VP44 is cooled with fuel instead of oil (as the old P7100 12valve pumps). When this problem occurs you will usually experience intermittent hard starts, white smoke and what's usually referred to as “The Dead Pedal”.
- Related Videos
- Related Articles
- Ask / Related Q&A
- Information on Air Intakes for Diesel Trucks
- Extreme Diesel Performance Part 1 Of 2
- Types of Diesel Engines in Cars
- Mitsubishi to Get Diesel From Peugeot
- Gm Daewoo Lacetti Sport Wagon and Lacetti Diesel Debuts on Jeju Island
- 1998.5-2002 Dodge Cummins Vp44 Injection Pump Failures
- Chinahanji Parts Plant
- Automobile industry : Disruptive technologies are the need of the hour !




The Ford F-150
By: Daniel Legal | 07/01/2010The Ford F Series is a series of pickup trucks sold by the Ford Motor Company for more than 50 years. The most popular model in the line of F series trucks is the Ford F-150. In the United States, the vehicle was the champion of sales for almost 23 years. The F-150 has been accepted as the best selling truck in overall sales for almost 40 years.
Selling Your Car , Truck Or S.U.V. - Getting It Ready For Sale
By: yanary | 07/01/2010It's come time to sell your car. Perhaps you have purchased a new car and the trade in wasn't enough? Perhaps you have bought a car privately and thus have an extra car to sell.
Used tow trucks for sale, Tow trucks for sale, Tow trucks in Massachusetts, Used towing trucks for sale, Wreckers in Massachusetts, Rollback trucks
By: woleez | 06/01/2010Truck Sales has been boosted many times since last 25 years at Lancaster, Massachusetts. While there are many good shops that have expanded as well as the parts department and service warehouse. A good Truck Sales shop have to kept up with the demand from the Tow Truck clientele that they service with unmatched customer service and the willingness to go the extra mile when it comes to what a customer wants.
Financing for freight and transportation brokerage
By: krishnajaniwriter@gmail.com | 06/01/2010Owning and operating a freight brokerage company has been considered a lucrative business. Being a freight broker truly can be rewarding, financially speaking. The freight brokerage business can also be very involved as far as keeping up with finance.
Trucks are the ladder for success for entire nation
By: Dolly | 06/01/2010Trucksntrailers.net is the website which is having huge varieties of trucks and trailers for sale online. These are the models with greater utilities and better benefits. All of these trucks are represented by many of the state dealers across the America and the most emphasised dealers are from the states of Florida, Michigan and Georgia.
Rollback truck for sale| Used wrecker truck parts| Tow truck parts for sale| Used towing trucks for sale| Used tow trucks for sale
By: woleez | 05/01/2010Our inventory of available tow trucks ranges from 2010 4 car carriers, 2 car carriers, wreckers, rollbacks and heavy duties. We strive to get the perfect fit for our clients, if you have a specific make, model and year in mind; we can get that for you. Crawford Trucks strives to offer competitive and fair rollback truck sales, tow truck sales and tow trucks in Massachusetts. Crawford Truck is more than willing to sell your truck on consignment and procure your new truck in the process.
Three Things to Know About International Harvester Truck Parts
By: Brian & Jeff | 02/01/2010Learn more about International Harvester Truck Parts and see if they are right for you at this time. Please read our unbiased review of International Harvester Truck Parts and make your final decision.
Led Light bar, Installing is a easy process by Edgeolite
By: Toni Donfrio | 01/01/2010Led brake light bar and light bar installation